• Contact Claims: 1-800-937-1937
  • Get a Free Quote: 1-800-283-2883
  • 1-800-245-2628
  • 9AM - 5PM EST
  • 1-800-365-5636
Viewing Blog

View All Blogs | View Blogs by badriance | View Blogs in Damage Avoidance

Tags for Why Boats Catch Fire

Seaworthy  Damageavoidance  Insurance  Fire  

<- Previous Blog by badriance | Next Blog by badriance ->

Why Boats Catch Fire

By badriance - Published June 01, 2009 - Viewed 9135 times

One problem with a fire aboard a boat is that unlike a house, where running across the street to escape the flames is an option, on a boat there’s no place to go but overboard. Unfortunately, this violates the second rule of boating: Stay with the boat. Ironically, if enough of what the boat is floating on can be brought into the boat, the fire can usually be put out. This, however, violates the first law of boating: Keep the water outside the boat.


Obviously, stopping fires from getting started in the first place is the best defense. Fortunately, the best source for learning how to prevent fires is right on hand at Seaworthy -- our Marine Insurance claim files. The files contain hundreds of fire-related claims which Seaworthy editors have spent many hours analyzing. Here’s a rundown.


Causes of Fires Started Aboard:


1)         AC and DC wiring/appliance  55%

            DC shorts/wiring                        30%

            DC engine voltage regulator       12%

            AC appliance/heater                    4%

            shore power                                4%

            AC wiring/panel                          2%

            DC battery charger                     2%

            AC power surge                         1%


The number one cause of fires on boats are DC wiring faults. Many fires are started by battery cables, bilge pump wires, and even instrument wires chafing on hard objects like vibrating engines or sharp-edged bulk-heads.


Shore power can be a problem area as well; 11% of fires were started by the boat’s AC system, frequently at the shore power inlet. A few fires every year are caused by AC heaters and other household appliances that were brought on board. Electrical fires can be hard to put out because the source of the heat (a shorted wire) can reignite the fire even after a fire extinguisher has been used, which is why your boat must have a main battery switch and/or AC breaker to turn off the boat’s entire electrical system.


2)         Engine/Transmission Overheat  24%

            Engine overheat                              19%

            Turbocharger overheat                     2%

            Transmission overheat                      2%

            Backfire                                           1%


Nearly a quarter of boat fires (24%) were started by propulsion systems overheating. Most frequently, an intake or exhaust cooling water passage was obstructed causing the engine to overheat and begin to melt down hoses and impellers. These fires tended to be less serious, but because of the amount of smoke they made, they got undivided attention, especially since the smoke was coming from an area with flammable fuels. Often the fires were simply smoldering rubber until someone made the mistake of opening he engine compartment and allowing fresh air to enter. The best way to put out a fire that’s in the engine compartment is to have an automatic extinguisher system do it for you. If you don’t have an automatic system, the next best course of action is to shut down the engine and use an extinguisher in a fireport if your boat has one; if not, crack open the hatch and discharge the extinguisher. Keeping the water intake lines and especially the exhaust manifolds and risers free of obstructions (weeds in the intake, rust in the exhaust) and replacing worn pump impellers will prevent most overheating fires.


3)         Fuel Leak                               8%


This might be the worst kind of fire to have on a boat. Many boats carry over a hundred gallons of gasoline on board and burning fuel can be hard to extinguish (95% of fuel-related fires were caused by gasoline). Typical problem areas are fuel lines, connections on the engine itself, and leaking fuel tanks. Fortunately, the first warning sign is usually a gas smell that is easily detected by the average human nose -- if you can smell raw gas, something’s wrong. Several fires were started by carelessness around gasoline; cleaning engines parts with gas, overfilling a fuel tank, and installing non-ignition-protected parts. One fire started when a member poured gas down a carburetor to start the engine. The engine backfired and caught the overhead on fire; the member jumped off the boat and ran to his house carrying the gas can, spilling gas along the way. The fire department report noted a zigzag burn pattern on the lawn up to the member’s front door. Fortunately, aside from some burned grass, there was no damage to the house. A gas leak has to be taken seriously since it has the potential to explode and destroy a boat -- that’s why it’s critical to run the bilge blower for four or five minutes before starting the engine. Diesel is not immune from igniting either -- one fire was started when a ruptured line strayed fuel on a hot manifold.


4) Miscellaneous                                7%


Some fires don’t fit into any category -- misdirected flares during a fishing tournament, anchoring in the wrong spot during a fireworks display, a child playing with matches, and even a case of spontaneous combustion from linseed-soaked rags. The only fire that couldn’t have been prevented by more care was one caused by lightning.


5) Unknown                                        5%


6) Stove                                              1%


Stove fires appear to be less common (1%) than in the past, probably due to fewer alcohol stoves being installed on new boats. Still, alcohol can be a dangerous fuel; thought it can’t explode, an alcohol flame is hard to see. One fire was started when a member tried to light the stove and gave up because he couldn’t see the flame. Unfortunately, he had succeeded, but didn’t realize it until he got a call from the fire department. Only one fire was started by propane; a portable stove fell off a counter and ignited a cushion.



Blog Comments

There are 0 blog comments.

Sorry there are no blog comments.

Post Blog Comments

Sorry but you must be logged in to submit comments.